笋头膳食纤维复合酶法改性工艺优化及其理化特性评价

方东亚; 郑亚凤

doi:10.19303/j.issn.1008-0384.2019.03.017

笋头膳食纤维复合酶法改性工艺优化及其理化特性评价

doi: 10.19303/j.issn.1008-0384.2019.03.017

方东亚,
郑亚凤^,

福建农林大学食品科学学院, 福建福州 350002

基金项目:

福建省高校青年自然科学基金重点项目 JZ160434

详细信息

作者简介:
方东亚(1994-), 女, 硕士研究生, 研究方向:农产品加工及贮藏(E-mail:fdongya@163.com)

通讯作者:
郑亚凤(1981-), 女, 教授, 研究方向:食品碳水化合物与营养(E-mail:zyffst@163.com)

中图分类号: TS209
计量
- 文章访问数: 966
- HTML全文浏览量: 165
- PDF下载量: 30
- 被引次数: 0
出版历程
- 收稿日期: 2018-09-12
- 修回日期: 2019-01-14
- 刊出日期: 2019-03-28

Enzymatic Hydrolysis for Producing Dietary Fibers from Bamboo Shoot Byproduct

FANG Dong-ya,
ZHENG Ya-feng^,

College of Food Science, Fujian Agriculture and Forestry University, Fuzhou, Fujian 350002, China

摘要

摘要: 目的笋头是笋加工的主要副产物，是来源广泛且成本低廉的膳食纤维原料。传统的热水法制备的笋头膳食纤维由于纤维颗粒大，口感粗糙，在食品中添加应用易造成品质下降。为了推动笋头膳食纤维在食品加工中的应用，本文研究了复合酶法改性工艺对笋头膳食纤维的粒径及理化特性的影响。方法以热水法制备的笋头膳食纤维为原料，以纤维粒径为评价指标，通过单因素试验研究复合酶添加量、时间、温度和pH值对纤维粒径的影响。根据单因素结果，进行以Box-Behnken试验设计为基础的响应面优化试验。比较分析了改性前后笋头膳食纤维的理化特性变化。结果复合酶法改性笋头膳食纤维的最优工艺条件为：复合酶添加量0.20%（纤维素酶：木聚糖酶=1：1），温度47℃，pH 5.4，时间2.0 h。以优化后的复合酶解法处理的笋头膳食纤维的纤维粒径（D₉₀）由（146.2±0.21）μm降低至（97.2±0.14）μm。相对于改性处理前的笋头膳食纤维，改性笋头膳食纤维的持水力、持油力和膨胀度分别提高1.30、2.16和1.64倍。结论经过工艺优化的复合酶法可显著减小笋头膳食纤维的纤维粒径，并显著提高纤维的持水力、持油力和膨胀度等理化性质。研究结果有利于推动笋头膳食纤维在功能食品加工中的应用。
- 笋头 /
- 膳食纤维 /
- 响应面 /
- 复合酶解
Abstract: Objective Enzymatic hydrolysis was studied and optimized to modify the otherwise long and tough fibers of the bottom portion of a bamboo shoot (BDF) for a low-cost source of dietary fiber. Method Various enzymes in varying dosages at different temperatures, pHs and digestion durations were applied on hot-water cooked BDF for the experiment. Size of the fibers was measured in a single factor test followed by a Box-Behnken response surface experiment at 3 levels of each factor to optimize the process. Physical properties of the raw material and the resulting dietary fibers were compared. Result The optimized hydrolysis was found to include 0.20% addition of cellulase:xylanase at 1:1 ratio, temperature at 47℃, pH at 5.4 and digestion for 2.0 h. The BDF size (D₉₀) decreased from(146.2±0.21) μm to (97.2±0.14) μm after the enzymatic hydrolysis. The water and oil holding capacities and expansion of the hydrolyzed BDF increased by 1.30-, 2.16-and 1.64-folds, respectively, over the pre-treatment samples. Conclusion The optimized composite enzymatic hydrolysis significantly reduced the fiber size and improved the physical properties of BDF making it as a dietary fiber ingredient feasible.
- bamboo shoot byproduct /
- dietary fiber /
- response surface experiment /
- composite enzymatic hydrolysis

HTML全文

图 1 复合酶添加量对笋头膳食纤维粒径的影响

Figure 1. Effect of enzyme dosage on size of dietary fibers from BDF

下载: 全尺寸图片幻灯片

图 2 酶解pH对笋头膳食纤维粒径的影响

Figure 2. Effect of pH on size of dietary fibers from BDF

下载: 全尺寸图片幻灯片

图 3 酶解温度对笋头膳食纤维粒径的影响

Figure 3. Effect of temperature on size of dietary fibers from BDF

下载: 全尺寸图片幻灯片

图 4 酶解时间对笋头膳食纤维粒径的影响

Figure 4. Effect of hydrolysis time on size of dietary fibers from BDF

下载: 全尺寸图片幻灯片

图 5 不同因素的3D响应面

Figure 5. 3D response surface contours on interaction of different factors

下载: 全尺寸图片幻灯片

表 1 响应面试验因素水平

Table 1. Factors and levels of response surface experiment

水平 Level	复合酶添加量 Composite enzyme dosage/%	酶解pH pH for enzymolysis	酶解温度 Temperature for enzymolysis/℃
-1	0.15	4.5	40
0	0.20	5.0	45
1	0.25	5.5	50

下载: 导出CSV

表 2 响应面分析方案及试验结果

Table 2. Response surface design and experimental results

试验号 Test number	A复合酶添加量 Composite enzyme dosages/%	B酶解温度 Temperature for enzymolysis/℃	C酶解pH pH for enzymolysis	粒径 Particle size/μm
1	-1	0	1	141.0
2	0	-1	1	143.6
3	-1	1	0	117.4
4	0	0	0	103.2
5	1	0	1	128.6
6	0	-1	-1	131.5
7	0	0	0	102.1
8	0	1	-1	106.8
9	1	-1	0	141.6
10	0	0	0	102.3
11	1	0	-1	111.5
12	1	1	0	112.3
13	-1	-1	0	138.5
14	-1	0	-1	113.0
15	0	0	0	106.6
16	0	1	1	123.4
17	0	0	0	103.5

下载: 导出CSV

表 3 响应面方差分析二次模型方差分析

Table 3. ANOVA for response surface model analysis of variance

方差来源 Variance source	平方和 Quadratic sum	自由度 Degree of freedom	均方 Mean square	F值 F-value	Probe>F	显著性 Significance
模型Model	3675.54	9	408.39	41.92	< 0.0001	**
复合酶添加量Composite enzyme dosages	31.6	1	31.6	3.24	0.1147
酶解温度Temperature for enzymolysis	1135.26	1	1135.26	116.53	< 0.0001	**
酶解pH pH for enzymolysis	680.8	1	680.8	69.88	< 0.0001	**
AB	16.81	1	16.81	1.73	0.2304
AC	29.7	1	29.7	3.05	0.1243
BC	5.06	1	5.06	0.52	0.4944
A²	469.09	1	469.09	48.15	0.0002	**
B²	750.97	1	750.97	77.09	< 0.0001	**
C²	374.42	1	374.42	38.43	0.0004	**
残差Residue value	68.19	7	9.74
失拟项Lack of fit	55.1	3	18.37	5.61	0.0645
净误差Net error	13.09	4	3.27
总离差Total deviation	3743.74	16
注：若Probe>F值< 0.05，则表示该指标显著，用表示；若Probe>F值< 0.01，则表示该指标极显著，用表示；R²=0.7590，R_Adj²=0.9584。 Note: When Probe>F is below 0.05, the corresponding index is labeled with “” to indicate significant difference. When Probe>F is below 0.01，the corresponding index is labeled with “**” to indicate extremely significant difference. R²=0.7590，R_Adj²=0.9584.

下载: 导出CSV

表 4 纤维样品持水力、持油力和膨胀度比较

Table 4. Water and oil holding capacities and expansion of fiber samples

样品 Samples	持水力 Water binding capacity/(g·g^-1)	持油力 Oil binding capacity/(g·g^-1)	膨胀度 Swelling capacity/(mL·g^-1)
酶解前纤维Nativefiber	7.31± 0.12b	0.91± 0.09b	2.8 ± 0.11b
酶解后纤维Modified fiber	9.51 ± 0.19a	1.97 ± 0.21a	4.6 ± 0.14a

下载: 导出CSV

参考文献(25)

[1]	刘杰.雷竹笋复合饮料的研发与生产工艺研究[D].长沙: 中南林业科技大学, 2014. LIU J. The content and determination of dietary fiber from peel husk[D]. Changsha: Central South University of Forestry and Technology, 2014.(in Chinese)
[2]	CHEICKNA D, HUI Z. Functional and physiological properties of total, soluble, and insoluble dietary fibres derived from defatted rice bran[J]. J Food Sci Technol, 2014, 51(12): 3878-3885. doi: 10.1007/s13197-013-0925-y
[3]	张茜, 杨莉, 刘毅.果皮果壳膳食纤维含量及性能测定[J].江西化工, 2014(4): 116-118. doi: 10.3969/j.issn.1008-3103.2014.04.038 ZHANG Q, YANG L, LIU Y. The content and determination of dietary fiber from peel husk[J]. Jiangxi Chemical Industry, 2014(4): 116-118.(in Chinese) doi: 10.3969/j.issn.1008-3103.2014.04.038
[4]	牛飞飞.果蔬膳食纤维粒径对其理化性质及加工性能的影响[D].无锡: 江南大学, 2016. NIU F F. The effect of particle size of dietary fiber on its physicochemical and processing properties[D]. Wuxi: Jiangnan University, 2016.(in Chinese)
[5]	宋玉.竹笋膳食纤维的改性及在中式香肠中的应用研究[D].贵州: 贵州大学, 2018. SONG Y. Modification of bamboo shoots dietary fiber and its application in Chinese sausages[D]. Guizhou: Guizhou University: 2018.(in Chinese)
[6]	刘玉凌.物理改性方竹笋膳食纤维理化性能及结构的研究[D].重庆: 西南大学, 2016. LIU Y L.Study on the physicochemical properties and structure of Chimonobambusa dietary fiber modified by physical ways[D]. Chongqing: Southwest University, 2016.(in Chinese)
[7]	陆红佳, 袁进文, 游玉明.粒度大小对姜渣膳食纤维功能特性的影响[J].中国调味品, 2018, 43(10): 37-42. doi: 10.3969/j.issn.1000-9973.2018.10.008 LU H J, YUAN J W, YOU Y M. Effect of particle size on the functional characteristis of dietary fiber from ginger slag[J]. China Condiment, 2018, 43(10): 37-42.(in Chinese) doi: 10.3969/j.issn.1000-9973.2018.10.008
[8]	张汪, 时超, 褚莹莹, 等.米糠膳食纤维提取工艺的研究进展[J].食品工程, 2016(4): 1-3. doi: 10.3969/j.issn.1673-6044.2016.04.001 ZHANG W, SHI C, CHU Y Y, et al. Research of rice bran dietary fiber extraction process[J]. Food Engineering, 2016(4): 1-3.(in Chinese) doi: 10.3969/j.issn.1673-6044.2016.04.001
[9]	齐惠.挤压-酶法联合制备豆渣水溶性膳食纤维及其性质研究[D].哈尔滨: 东北农业大学, 2016. QI H. Preparation of soluble dietary fiber from soybean residues by extrusion-enzymatic technology and its properties[D]. Haerbin: Northeast Agriculture University, 2016.(in Chinese)
[10]	林良美.笋壳活性膳食纤维的提取及降糖降脂功能特性研究[D].福州: 福建农林大学, 2016. LIN L M. Extraction, hypoglycemic and hypolipidemic effects of bioactive dietary fiber from bamboo shoot shell[D]. Fuzhou: Fujian Agriculture and Forestry University, 2016.(in Chinese)
[11]	陈琼玲.响应面优化苣荬菜中水溶性膳食纤维提取及其理化性质[J].食品工业, 2017(10): 93-97. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spgy201710024 CHEN Q L. Optimazation of Extraction Process of Soluble Dietary Fiber from Sonchus arvensis L. by Response Surface Methodology and Its Properties[J]. The Food Industry, 2017(10): 93-97.(in Chinese) http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spgy201710024
[12]	方吉雷, 葛青, 毛建卫, 等.超微粉碎对竹粉膳食纤维功能特性的影响[J].食品工业科技, 2017, 38(17): 50-55. http://d.old.wanfangdata.com.cn/Periodical/spgykj201717010 FANG J L, GE Q, MAO J W, et al. Effect of superfine pulverizing on properties of bamboo powder dietary fiber[J]. Science and Technology of Food Industry, 2017, 38(17): 50-55.(in Chinese) http://d.old.wanfangdata.com.cn/Periodical/spgykj201717010
[13]	刘欢, 顾邢伟, 王雪, 等.玉米秸秆超微粉碎与醇解液化研究[J].农业机械学报, 2015, 46(11): 214-20. doi: 10.6041/j.issn.1000-1298.2015.11.029 LIU H, GU X W, WANG X, et al. Ultrafine grinding and alcolhol liquefaction for corn stover[J]. Transactions of the Chinese Society for Agricultural Machinery, 2015, 46(11): 214-20.(in Chinese) doi: 10.6041/j.issn.1000-1298.2015.11.029
[14]	张馨月, 刘海棠, 刘忠, 等.咖啡渣膳食纤维超高压改性吸水润胀性能的研究[J].食品工业, 2018(3): 134-137. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spgy201803034 ZHANG X Y, LIU H T, LIU Z, et al. Study on the swelling properties of coffee residue dietary fiber by ultra-high pressure modification[J]. The Food Industry, 2018(3): 134-137.(in Chinese) http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spgy201803034
[15]	REQUENA M C, GONZ LEZ C N A, BARRAG N L A P, et al. Functional and physico-chemical properties of six desert-sources of dietary fiber[J]. Food Bioscience, 2016, 16:26-31. doi: 10.1016/j.fbio.2016.08.001
[16]	CHEN J, GAO D, YANG L, et al. Effect of microfluidization process on the functional properties of insoluble dietary fiber[J]. Food Research International, 2013, 54(2): 1821-1827. doi: 10.1016/j.foodres.2013.09.025
[17]	石亚中, 方娇龙, 钱时权, 等.响应曲面法优化纤维素酶酶解提取工艺[J].食品科学, 2013, 34(4): 75-79. http://d.old.wanfangdata.com.cn/Periodical/spkx201304016 SHI Y Z, FANG J L, QIAN S Q, et al. Response surface methodology for the optimization of enzymatic extraction of resveratrol grape pomace with cellulase[J]Food Science, 2013, 34(4): 75-79.(in Chinese) http://d.old.wanfangdata.com.cn/Periodical/spkx201304016
[18]	ÇINAR Ï. Effects of cellulase and pectinase concentrations on the colour yield of enzyme extracted plant carotenoids[J]. Process Biochemistry, 2005, 40(2): 945-949. doi: 10.1016/j.procbio.2004.02.022
[19]	赵能, 罗安伟, 姚婕, 等.响应面试验优化胡萝卜浆复合酶解工艺[J].食品科学, 2015, 36(16): 83-87. doi: 10.7506/spkx1002-6630-201516015 ZHAO N, LUO A W, YAO J, et al. Optimization of enzymatic hydrolysis of Carrot Pulp with cellulase and pectinase for increased juice yield by response surface methodology[J]. Food Science, 2015, 36(16): 83-87.(in Chinese) doi: 10.7506/spkx1002-6630-201516015
[20]	陈开霜, 宋艳, 魏熠, 等.响应面法优化纤维素酶水解南瓜工艺的研究[J].食品工业, 2017(9): 66-70. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spgy201709017 CHEN K S, SONG Y, WEI Y, et al. Optimization of cellulase hydrolysis of Pumpkin by response surface methodology[J]. The Food Industry, 2017(9): 66-70.(in Chinese) http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spgy201709017
[21]	肖南, 林敏欣.响应面分析法优化纤维素酶提取陈皮中橙皮苷工艺的研究[J].农产品加工, 2016(16): 18-23. http://d.old.wanfangdata.com.cn/Periodical/ncpjg-cxb201608005 XIAO N, LIN M X. Study on Cellulose Enzyme-assisted Extraction of Hesperidin from Pericarpium Citri Reticulatae with Response Surface Analysis[J]. Farm Products Processing, 2016(16): 18-23.(in Chinese) http://d.old.wanfangdata.com.cn/Periodical/ncpjg-cxb201608005
[22]	卢忠英, 王云洋, 鲁道旺, 等.响应面与酶法优化拐枣膳食纤维的提取工艺[J].食品研究与开发, 2017, 38(21): 24-28. doi: 10.3969/j.issn.1005-6521.2017.21.006 LU Z Y, WANG Y Y, LU D W, et al. Optimization extraction of dietary fiber from hovenia dulcis by enzymolysis and response surface methodology[J]. Food Research and Development, 2017, 38(21): 24-28.(in Chinese) doi: 10.3969/j.issn.1005-6521.2017.21.006
[23]	师静, 林占熺, 林冬梅, 等.巨菌草纤维素的酶解条件[J].草业科学, 2014, 31(4): 760-765. http://d.old.wanfangdata.com.cn/Periodical/caoyekx201404028 SHI J, LIN Z X, LIN D M, et al. Enzymolysis conditions of Pennisetumsp cellulose[J]. Pratacultural Science, 2014, 31(4): 760-765.(in Chinese) http://d.old.wanfangdata.com.cn/Periodical/caoyekx201404028
[24]	张建安, 闫科.木素对纤维素酶解的影响及纤维素酶解[J].化学工程, 2000, 28(1): 39-41. http://d.old.wanfangdata.com.cn/Periodical/hxgc200001009 ZHANG J A, YAN K. Effects of lignin on cellulolysis and cellulolysis[J]. Chemical Engineering(China), 2000, 28(1): 39-41.(in Chinese) http://d.old.wanfangdata.com.cn/Periodical/hxgc200001009
[25]	黄冬云, 钱海峰, 苑华宁, 等.木聚糖酶制取米糠膳食纤维的功能性质[J].食品与发酵工业, 2013, 39(12): 30-34. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spyfx201312006 HUANG D Y, QIAN H F, YUAN H N, et al. Study on xylanase enzyme modified the rice bran dietary fibre and its functional properties[J]. Food and Fermentation Industries, 2013, 39(12): 30-34.(in Chinese) http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=spyfx201312006